Product ID:CAVI-LINE THINNER, 674076
MSDS Date:11/20/1991
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CKYVY

CAULK/DENTSPLY

CLARKE AND LAKEVIEW AVES.
MILFORD, DE 19963-0359

Emergency Phone: 302-422-4511

Info Phone: (302) 422-4511

Cage: 56820

CAULK/DENTSPLY

MILFORD, DE 19963-0359

Telephone: (302) 422-4511

Cage: 56820

75 PPM-NIOSH, 10 HR.

CAS: 75-09-2

RTECS: PA8050000

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TRICHLOROTRIFLUOROETHANE

CAS: 76-13-1

RTECS: KJ4000000

OSHA PEL 7600 MG/M3;1000 PPM

ACGIH TLV: 7670 MG/M3;1000 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:CHLOROFLUOROCARBON (CFC) MATERIALS
HAVE PRODUCED SENSITIZATION OF THE MYOCARDIUM TO EPINEPHRINE IN
LABORATORY ANIMALS AND COULD HAVE A SIMILAR EFFECT IN HUMANS. THE
USE OF EPINEPHRINE MAY BE CONTRA-IN DICATED EXCEPT FOR LIFE
SUSTAINING USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO CFCS .
INHALATION: PROLONGED, EXCESSIVE BREATHING OF VAPORS MAY RESULT IN
LUNG AND KIDNEY DAMAGE. MAY ALSO CA USE CARDIAC ARRHYTHMIAS. EYES:
MAY CAUSE REVERSIBLE CORNEAL INJURY. SKIN: MAY DRY THE SKIN.
PROLONGED OR REPEATED CONTACT MAY IRRITATE THE SKIN, CAUSING
(TOXICOLOGICAL)
Explanation of Carcinogenicity:DICHLOROMETHANE (METHYLENE CHLORIDE)
[75-09-2]: IARC GROUP 2B. VOL. 71; 1999. VOL. 41; 1986. P. 43-68.
NTP NINTH REPORT ON CARCINOGENS, LISTED: REASONABLY ANTICIPATED TO
BE A CARCINOGEN. OSHA REGU LATED 29 CFR. 1910.1052.
Effects of Overexposure:INHALATION: LIGHTHEADEDNESS, GIDDINESS,
SHORTNESS OF BREATH AND POSSIBLE NARCOSIS. ALSO CAUSES HEADACHE,
NAUSEA & VOMITING AFTER PROLONGED EXPOSURE. EXCESSIVE BREATHING OF
VAPORS MAY CAUSE LUNG AND KI DNEY DAMAGE, UNCONCIOUSNESS & DEATH.
SKIN: MAY RESULT IN DRY SKIN. EYES: MAY CAUSE PAIN & IRRITATION.
INGESTION: MAY CAUSE NAUSEA, VOMITING & ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:PERSONS WITH ANGINA OR HEART
DISEASE OR THOSE WHO ARE SMOKERS OR HEAVY DRINKERS SHOULD NOT BE
EXPOSED TO THIS PRODUCT.

First Aid:INHALED: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
NOT BREATHING. GET MEDICAL ATTENTION. EYES: FLUSH WITH WATER FOR AT
LEAST 15 MIN. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
SWALLOWED: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION
IMMEDIATELY. IF VOMITING OCCURS SPONTANEOUS, KEEP VICTIMS HEAD
BELOW HIS HIPS. DO NOT GIVE EPINEPHRINE OR SIMILAR DRUGS. SKIN
CONTACT: FLUSH WITH COPIOUS AMOUNTS OF WATER. CONTACT A PHYSICIAN
.

Flash Point:NON-FLAMMABLE
Lower Limits:N.E.
Upper Limits:N.E.
Extinguishing Media:THIS MATERIAL IS NOT COMBUSTIBLE. USE EXTINGUISHING
MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA AND
FULL PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL NEARBY
CONTAINERS AND STRUCTURE EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE FLUORIDES, CHLORIDES AND PHOSGENE . EXTINGUISH NEARBY
SOURCES OF IGNITION SINCE VAPORS DECOMPOSE TO HAZARDOUS PRODUCTS AT
HIGH TEMPERATURES.

Spill Release Procedures:WEAR FULL PROTECTIVE CLOTHING INCLUDING NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS & EYE PROTECTION.
EXTINGUISH ALL IGNITION SOURCES. ABSORB THE SPILL WITH INERT
MATERIAL AND PLACE IN DOT-APPRO VED WASTE CONTAINERS. KEEP OUT OF
SEWERS, STORM DRAINS, SURFACE WATERS AND SOIL.

Handling and Storage Precautions:STORAGE: STORE AT 75 DEGREES F OR
BELOW. KEEP TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY FROM FOOD &
BEVERAGES. HANDLING: WASH THOROUGHLY AFTER HANDLING. DO NOT WELD,
CUT, GRIND OR DRILL NEAR THIS MA TERIAL.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE VICINITY
OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR UV
RADIATION MAY CAUSE THE FORMATION OF FLUORIDES, CHLORIDES AND
PHOSGENE . NOTE: V APORS OF THIS MATERIAL ARE DENSER THAN AIR AND
WILL COLLECT IN LOW-LYING AREAS.

Respiratory Protection:A NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS IN PRESSURE DEMAND MODE IF USE CONDITIONS GENERATE VAPOR
OR MISTS. CANISTER RESPIRATORS MAY BE INEFFECTIVE.
Ventilation:LOCAL EXHAUST: CAPABLE OF MAINTAINING EMISSIONS AT POINT OF
USE BELOW PEL.
Protective Gloves:VITON GLOVES.
Eye Protection:ANSI-APPROVED CHEMICAL SAFETY GOGGLES AND FULL
FACESHIELD .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . LONG-SLEEVED SHIRT, TROUSERS, SAFETY SHOES.
Work Hygienic Practices:OBSERVE NORMAL CARE WHEN WORKING WITH
CHEMICALS. WASH THOROUGHLY AFTER HANDLING. KEEP AWAY FROM FOOD AND
BEVERAGES.
Supplemental Safety and Health

Boiling Pt:=40.C, 104.F
Melt/Freeze Pt:M.P/F.P Text:N.E.
Vapor Pres:N.E.
Vapor Density:2.9
Spec Gravity:1.4 G/CM3
Evaporation Rate & Reference:< 1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, WATER WHITE LIQUID WITH CHARACTERISTIC ODOR.

Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS, ALUMINUM, ZINC, WATER, MOIST AIR,
OXIDIZING MATERIALS.
Stability Condition to Avoid:OPEN FLAMES, WELDING ARCS OR OTHER HIGH
TEMPERATURE SOURCES WHICH MAY INDUCE THERMAL DECOMPOSITION.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROCHLORIC ACID, CHLORINE, PHOSGENE, HYDROGEN FLUORIDE.
Conditions to Avoid Polymerization:OPEN FLAMES, WELDING ARCS OR OTHER
HIGH TEMPERATURE SOURCES WHICH MAY INDUCE THERMAL DECOMPOSITION.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Toxicological Information:HEALTH HAZARDS ACUTE AND CHRONIC (CONT'D):
DERMATITIS. SWALLOWED: METHYLENE CHLORIDE IS METABOLIZED IN THE
BODY TO CARBON MONOXIDE. ELEVATED CARBOXYHEMOGLOBIN MAY RESULT
AFTER CHRONIC EXPOSURE.